(new format -- under construction)

From VLGWiki

THIS SITE IS CURRENTLY UNDER CONSTRUCTION -- EXCUSE OUR DUST :)

Welcome to the VLG Wiki!

Introduction (How to Use the VLG Wiki Manual; Vehicle I.D. Info; General Repair; Vehicle Lift)

Maintenance (General Maintenance; Maintenance Schedule; Maintenance Operations)

Engine Mechanical (Troubleshooting; Idle HC/CO Concentration; Compression Check; Timing Chain/Belt; Cylinder Head; Cylinder Block)

Emission Control System (System Purpose; Component Layout; Postivie Crankcase Ventilation (PCV) System; Fuel Evaporative Emission Control (EVAP) System; Dash Pot (DP) System; Exhaust Gas Recirculation (EGR) System; Catalytic Converter)

Fuel System (System Description; Precautions; Inspection Precautions; Troubleshooting; Diagnosis System; Gas Tank; Fuel Pump; Fuel Lines & Fittings)

Cooling System (Troubleshooting; Check and Replace Engine Coolant; Water Pump; Thermostat; Radiator)

Lubrication System (Troubleshooting; Oil Pressure Check; Replacement of Engine Oil and Oil Filter; Oil Pump; Oil Pressure Regulator)

Ignition System (Key Blanks; Precautions; Troubleshooting; Electronic Spark Advance; On-Vehicle Inspection; Distributor; Coil)

Starting System (Troubleshooting; Starting System Circuit; Starter)

Charging System (Precautions; Troubleshooting; On-Vehicle Inspection; Alternator)

Clutch (Troubleshooting; Check and Adjustment of Clutch Pedal; Bleeding of Clutch System; Clutch Master Cylinder; Clutch Release Cylinder; Clutch Unit)

Manual Transmission (Troubleshooting; Types of Transmissions; Removal; Components; Dissembly; Inspection; Assembly; Installation)

Automatic Transmission (Espada only?)

Propeller Shaft (Precautions; Troubleshooting; Propeller Shaft; Donut or U-Joints)

Front Axle and Suspension (Troubleshooting; Front Wheel Alignment; Front Axle Hub; Front Axle Shock Absorber; Front Suspension)

Rear Axle and Suspension (Troublshooting; IRS Type Rear Axle Shaft; Rear Drive Shaft; IRS Type Differential; Limited Slip Differential; IRS Type Rear Suspension; Differential Support Member; Rear Wheel Alignment)

Brake System (Precautions; Troubleshooting; Checks and Adjustments; Master Cylinder; Brake Booster; Front Brake; Rear Brake; Brake Hoses and Tubes; Parking Brake)

Steering (Precautions; Troubleshooting; Steering Check; Steering Main Shaft; Power Steering)

Body Electrical System (Precautions; Location of Switches and Relays; Switches; Lighting; Wiper and Washer; Instruments and Sender Gauges; Rear Window Defogger; Heater; Illuminated Entry System; Power Window; Sun Roof; Cruise Control System; Remote Control Mirror; Radio, Stereo, Tape Player and Antenna; Clock)

Body & Trim (Introduction, Hood, Front Door, Back Door, Moulding, Windshield, Quarter Window Glass, Back Door Glass; Sun Roof, Safety Pad, Body Dimensions)

Interior (Seats, Doors, Dash, Carpet, Materials, Fixtures)

Air Condition System (Precautions; Troubleshooting; Special Tools and Test Equipment; Air Conditioning System Circuit; Refrigeration System; Functional Test and Adjustment; System Components; Compressor, Condenser; Receiver; Cooling Unit; Refrigerant Lines; Vacuum Switching Valve)

Service Specifications (Maintenance; Engine Mechanical; EFI System; Cooling System; Lubrication System; Ignition System; Starting System; Charging System; Clutch; Manual Transmission; Automatic Transmission; Properller Shaft; Front Axle and Suspension; Rear Axle and Suspension; Brake System; Steering; Lubricant)

Standard Bolt Tightening Torque

SI Metric Conversion Table

SST

Electrical Wiring Diagrams